Ford Transit Custom Engine Repair and Rebuild

Ford Transit Custom engine repair carried out properly the first time

The Ford Transit Custom is a familiar sight on British roads and for the most part it is a car that owners are happy with. The problems start when the 2.0 EcoBlue diesel develops one of the faults that this engine family is known for. Owners usually notice something small at first. A noise on a cold morning, a warning light that comes and goes, an oil level that will not stay where it should be. Left alone those small signs turn into a bill that runs into thousands, because once the lubrication inside a modern engine is compromised the damage spreads quickly through the bearings, the turbo and the cylinder head.

We repair and rebuild Ford engines every week, so we already know what to look for on a Ford Transit Custom. The main fault we see is wet timing belt can deteriorate and block the oil supply. That single sentence covers a chain of events that starts long before the engine finally gives up, and understanding it is the difference between a sensible repair and a very expensive replacement. Our job is to find the root cause, put it right with the correct parts, and hand the vehicle back with an engine that will do many more miles.

Everything is done in house. The engine comes out, it is stripped on the bench, every component is measured against the manufacturer figures, and the wear pattern tells us the story of how the failure happened. Only then do we quote for the rebuild. That approach protects you, because you are not paying for guesswork and you are not paying twice when a cheaper fix fails a few months later.

Ford Transit Custom engine variants and engine codes we work on

The 2.0 EcoBlue diesel appears in the Ford Transit Custom in several outputs. Knowing the exact variant matters because the internals, the turbo arrangement and the service parts change between them. These are the versions we handle.

• 2.0 EcoBlue 105 with 105 brake horsepower
• 2.0 EcoBlue 130 with 130 brake horsepower
• 2.0 EcoBlue 170 with 170 brake horsepower
• 2.0 EcoBlue 185 with 185 brake horsepower
• 2.0 EcoBlue 213 twin turbo with 213 brake horsepower

The engine codes stamped on these units include YLF6, YMF6, YN2S, YLFS, BJFA, BKFA, SAFA. You will normally find the code on a machined pad on the block or on the vehicle identification plate. If you are not sure which one you have, send us the registration and we will identify it for you before we quote. Getting the code right first time means we order the correct parts and the rebuild is not held up waiting for the right kit.

Main causes of Ford Transit Custom engine failure

Engines rarely fail without warning. On the Ford Transit Custom the failures follow a pattern and each one has a cause that can be identified during the strip down. These are the causes we record most often.

• The wet timing belt breaks up in the oil and blocks the pick up pipe
• The oil pump drive belt fails and pressure collapses under load
• High mileage motorway work with delayed oil changes
• Turbocharger and camshaft bearing damage after oil starvation
• Injector seal leaks that carbon up the head and contaminate the oil

Most of these causes share the same root. Oil that is old, thin, contaminated or simply not reaching the right places. Modern engines run tight clearances and high pressures, and they rely on a thin film of oil to keep metal apart. When that film breaks down the crankshaft bearings pick up first, then the camshaft journals, then the turbo. By the time a driver hears a knock the internal damage is already extensive, which is why we always tell customers to stop driving as soon as an oil warning appears.

Symptoms of a failing Ford Transit Custom engine

If you recognise any of the following on your Transit Custom, get in touch before the fault develops further. A repair caught early is very often a fraction of the cost of a full rebuild.

• A low oil pressure light on a hot engine at idle
• A rattle at start up from the front timing case
• A heavy knock from the bottom end after a warning light is ignored
• Loss of power with limp mode on the motorway
• Metallic glitter in the drained oil

Owners often tell us that a main dealer or a local garage has already looked at the car and quoted for a replacement engine. That is understandable because a general garage is not set up to rebuild an engine on site. We are. Our benches, our measuring equipment and our experience with the 2.0 EcoBlue diesel mean we can look inside the engine and give you a repair option that a general workshop cannot.

What a Ford Transit Custom engine rebuild includes

Every rebuild starts with a full strip down and a written report. We photograph the damage so you can see exactly what we found. The block is cleaned and measured, the crankshaft is checked for wear and ovality, the cylinder head is pressure tested and skimmed where needed, and any component outside tolerance is replaced rather than reused.

We fit genuine belt kits, oil pumps, crankshafts, bearings, injectors seals and gaskets. OEM parts cost more than pattern parts and we use them anyway, because the failures we deal with are so often caused by somebody trying to save money on a component that was never up to the job. The oil system gets particular attention. The pump, the pick up, the galleries and the cooler are all cleaned or replaced, since a rebuilt engine fed by a contaminated oil system will not survive.

Once the engine is back together it is run and tested before the vehicle leaves us. We check oil pressure at temperature, we road test the car, and we make sure there are no stored fault codes. Then we give you clear advice on the first oil change, the service interval we recommend and the driving habits that will keep the 2.0 EcoBlue diesel healthy for the long term.

Ford Transit Custom engine repair near me across the UK

We are asked about engine repair near me every day, and the honest answer is that the nearest garage is not always the right one for an engine rebuild. Our workshops are in Reading, Southampton, Leicester, Macclesfield, Manchester, and our collection service brings vehicles in from all over the country at no drama to the owner. That means you get a specialist rebuild wherever you live rather than a general repair down the road.

We carry out Ford Transit Custom engine repair for customers in Telford, Crawley, Wakefield, Walsall, Macclesfield, Edinburgh, Derby, Portsmouth, Preston, Bath, Hull, Wigan and many more towns and cities. If your postcode is not listed then it almost certainly still falls inside our collection area, so please ask.

• Ford Transit Custom engine repair Telford
• Ford Transit Custom engine repair Crawley
• Ford Transit Custom engine repair Wakefield
• Ford Transit Custom engine repair Walsall
• Ford Transit Custom engine repair Macclesfield
• Ford Transit Custom engine repair Edinburgh
• Ford Transit Custom engine repair Derby
• Ford Transit Custom engine repair Portsmouth
• Ford Transit Custom engine repair Preston
• Ford Transit Custom engine repair Bath
• Ford Transit Custom engine repair Hull
• Ford Transit Custom engine repair Wigan
• Ford Transit Custom engine repair Chelmsford
• Ford Transit Custom engine repair London
• Ford Transit Custom engine repair Liverpool
• Ford Transit Custom engine repair Stoke on Trent
• Ford Transit Custom engine repair Northampton
• Ford Transit Custom engine repair Chester
• Ford Transit Custom engine repair Watford
• Ford Transit Custom engine repair Doncaster
• Ford Transit Custom engine repair Dudley
• Ford Transit Custom engine repair Manchester
• Ford Transit Custom engine repair Glasgow
• Ford Transit Custom engine repair Nottingham

Fleet operators and van owners are looked after in the same way. Downtime costs money, so we prioritise commercial vehicles and keep common parts on the shelf. If you run several vehicles with the same engine we can also advise on the servicing changes that will stop the rest of the fleet following the same path.

Why owners choose us for Ford engine work

Forty four years of engine building is a long time. In that period we have rebuilt everything from ordinary family cars to award winning show vehicles, and the discipline is the same every time. Measure everything, replace what is worn, use the correct parts and test the result. That is why we are comfortable working on engines that other people describe as scrap.

We are also straight with people. If a Ford Transit Custom has been run so far past the point of failure that a rebuild no longer makes financial sense, we will say so and explain the alternatives. Most of the time a repair is the better route, and our page on repair versus a used engine explains why a second hand unit with unknown history can end up costing you the labour twice.

You can read more about the underlying mechanical causes in our engine failure guide, see typical costs on the prices page or check the frequently asked questions for warranty and timescale details.

Get a price for your Ford Transit Custom engine repair

Send us the registration, the mileage and a short description of the symptoms. We will tell you what we think has happened, what the likely repair involves and what it will cost. There is no charge for the quote and no pressure to book. If you would rather talk it through, call 0333 050 9802 and you will speak to somebody who understands the 2.0 EcoBlue diesel rather than a call centre.